THERMAL SCIENCE

International Scientific Journal

Thermal Science - Online First

online first only

Effect of an axial hole on natural convection heat transfer from a cylindrical pin fin attached to a horizontal plate

ABSTRACT
Heat transfer under laminar natural convection from a hollow cylindrical fin mounted on a horizontal base plate has been numerically studied. The flow outside the fin is much stronger than that inside the hole and as a consequence the rate of heat transfer from a hollow fin is primarily due to the contribution by the outer surface of the fin. Fortunately, the rate of heat transfer is not negatively affected by the presence of the hole at the fin centre. On the contrary, when the Grashof number is higher or the hole diameter is bigger, the inside surface contributes marginally to the heat transfer. A hollow fin saves material and weighs less compared to a solid fin. So, this feature may be exploited.
KEYWORDS
PAPER SUBMITTED: 2016-02-13
PAPER REVISED: 2016-09-15
PAPER ACCEPTED: 2016-10-03
PUBLISHED ONLINE: 2016-11-06
DOI REFERENCE: https://doi.org/10.2298/TSCI160213258M
REFERENCES
  1. Charles, R., Wang, C. C., A Novel Heat Dissipation Fin Design Applicable for Natural Convection Augmentation, International Communications in Heat and Mass Transfer, 59 (2014), pp. 24-59.
  2. Dogan, M., Sivrioglu, M., Yılmaz, O., Numerical Analysis of Natural Convection and Radiation Heat Transfer from Various Shaped Thin Fin-arrays Placed on a Horizontal Plate - A Conjugate Analysis, Energy Conversion and Management, 77 (2014), pp. 78-88.
  3. Huang, R. T., Sheu, W. J., Li, H. Y., Wang, C. C., Natural Convection Heat Transfer from Square Pin Fin Heat sinks Subject to the Influence of Orientation, Semiconductor Thermal Measurement and Management Symposium, 2006 IEEE Twenty-Second Annual IEEE.
  4. Ahmadi, M., Mostafavi, G., Bahrami, G., Natural Convection from Rectangular Interrupted Fins, International Journal of Thermal Sciences, 82 (2014), pp. 62-71.
  5. Tari, I., Mehrtash, M., Natural Convection Heat Transfer from Horizontal and Slightly Inclined Plate-fin Heat sinks, Applied Thermal Engineering, 61 (2013), pp. 728-736.
  6. Bhanja, D., Kundu, B., Mandal, P. K., Thermal Analysis of Porous Pin Fin used for Electronic Cooling, Procedia Engineering, 64 (2013), pp. 956-965.
  7. Zografos, A. I., Sunderland, J. E., Natural Convection from Pin Fin Arrays, Experimental Thermal and Fluid Science, 3 (1990), 4, pp. 440-444.
  8. Sparrow, E. M., Vemuri, S. B., Natural Convection/Radiation Heat Transfer From Highly Populated Pin Fin Arrays, J. Heat Transfer, 107 (1985), pp. 190-197.
  9. Jang, D., Yu, S. H., Lee, K. S., Multidisciplinary Optimization of a Pin-fin Radial Heat sink for LED Lighting Applications, International Journal of Heat and Mass Transfer, 55 (2012), pp. 515-521.
  10. Haldar, S. C., Natural Convection about a Cylindrical Pin Element on a Horizontal Plate, International Journal of Thermal Sc., 49 (2010), pp. 1977-1983.
  11. Kobus, C. J., Oshio, T., Predicting the Thermal Performance Characteristics of Staggered Vertical Pin Fin Array Heat sinks under Combined mode Radiation and Mixed Convection with Impinging Flow, International Journal of Heat and Mass Transfer, 48 (2005), pp. 2684-2696.
  12. Bocu, Z., Altac, Z., Laminar Natural Convection Heat Transfer and Air Flow in Three dimensional Rectangular Enclosures with Pin Arrays Attached to Hot Wall, Applied Thermal Engineering, 31 (2011), pp. 3189-3195.
  13. Elshafei, E. A. M., Natural Convection Heat Transfer from a Heat sink with Hollow/Perforated Circular Pin Fns, Energy, 35 (2010), pp. 2870-2877.
  14. Qiu, S., Xu, P., Geng, L., Mujumdar, A. S., Jiang, Z., Yang, J., Enhanced 353 Heat Transfer Characteristics of Conjugated Air Jet Impingement on a Finned Heat sink, Thermal Science, DOI:10.2298/TSCI141229030Q.
  15. Anandan, S. S., Ramalingam, V., Thermal Management of Electronics: A Review of Literature, Thermal Science, 12 (2008), 2, pp. 5-26.
  16. Leonard, B. P., Bounded Higher-order Upwind Multidimensional Finite-volume Convection diffusion Algorithms, in: Adv. in Num. Heat Transfer (Ed. W.J. Minkowycz, E.M. Sparrow), Vol.1, Taylor and Francis 2000.
  17. Sharma, A., Eswaran, V., Conservative and Consistent Implementation and Systematic Comparison of SOU and QUICK Schemes for Recirculating Flow Computation on a Nonstaggered Grid, Proc. 2nd Int. and 29th 363 National FMEP conf. Roorkee, India, 2002, pp. 351-358.